华石涂料质感仿砖施工工艺

华石涂料质感仿砖施工工艺 华石质感仿砖涂料施工工艺 目录 1、工程施工流程图 ................................ 2 2、施工方法 ...................................... 3 (1)基面处理 ................................. 3 (2)封闭底漆施工 ............................. 3 (3)分格及成品保护 ........................... 4 (4)仿砖涂料施工 ............................. 4 (5)去除分格胶带 ............................. 4 (6)清理、整修: ............................. 5 people. 6. measures to avoid loss of life or damage to property. 2.19 the mullion installation 1. Note: vertical installation in all curtain wall installation process due to its large amount of inconvenience of construction, high precision and play a very important role. If mullion is installed, the entire scheduleselect key, critical layer to clean, prevent debris impact on Ravel, identify key points and key layer fixed reinforced this point, and use on this level to take level so that horizontal lines as needed. (5) according to the curtain wall construction, simple key levels are not sufficient to determine the vertical position, in order to ensure the error limits of vertical installation, put the line ... Personnel 华石质感仿砖涂料施工工艺 1、工程施工流程图 (1)基面处理 (2)封闭底漆施工 (3)分格及成品保护 (4)仿砖涂料施工 (5)去除分格胶带 (6)清理、整修 people. 6. measures to avoid loss of life or damage to property. 2.19 the mullion installation 1. Note: vertical installation in all curtain wall installation process due to its large amount of inconvenience of construction, high precision and play a very important role. If mullion is installed, the entire scheduleselect key, critical layer to clean, prevent debris impact on Ravel, identify key points and key layer fixed reinforced this point, and use on this level to take level so that horizontal lines as needed. (5) according to the curtain wall construction, simple key levels are not sufficient to determine the vertical position, in order to ensure the error limits of vertical installation, put the line ... Personnel 2、施工方法 (1)基面处理 1、水泥层养护期需在20天左右，干燥、平整(二公尺落差,2mm); 2、含水率小于8%，PH值小于10，且有一定的承载力; 3、施工前需清除 表 关于同志近三年现实表现材料材料类招标技术评分表图表与交易pdf视力表打印pdf用图表说话 pdf 面的灰浆，浮灰等附着物; 4、空洞剔除，抹涂修补的水泥面应进行去碱处理; 5、将疏松粗糙的墙面铲除，修补至密实; (2)封闭底漆施工 1)以达到增加涂层附着力，延长饰面使用时间，增加基层强度，调整基层酸碱性及含水率。 )涂刷时应使用毛刷或滚涂，并力求均匀涂布。 2 3)采用交叉滚涂方法，保证施工无遗漏，涂膜均匀。 4)涂料施工必须由建筑物自上而下进行，每次涂刷以自然分割缝、阴阳角交接处或落水管为界，每个涂刷面应尽量一次完成。 5)不符合技术要求的，修补处理。 6)技术要求 目 测 涂膜均匀，无漏涂 手抹 表面应被涂膜包围，手抹无灰质感 重量面积比 符合标准要求 表干 符合标准要求 干燥时间 25? 实干 符合标准要求 7)底漆涂布须等干燥(约12小时)才可进行下道工序施工。 8)此底漆工序涂刷1遍，采用厦光专用黑色底漆涂刷1遍。 3 people. 6. measures to avoid loss of life or damage to property. 2.19 the mullion installation 1. Note: vertical installation in all curtain wall installation process due to its large amount of inconvenience of construction, high precision and play a very important role. If mullion is installed, the entire scheduleselect key, critical layer to clean, prevent debris impact on Ravel, identify key points and key layer fixed reinforced this point, and use on this level to take level so that horizontal lines as needed. (5) according to the curtain wall construction, simple key levels are not sufficient to determine the vertical position, in order to ensure the error limits of vertical installation, put the line ... Personnel (3)分格及成品保护 A. 底漆干燥后，用墨线根据砖面 设计 领导形象设计圆作业设计ao工艺污水处理厂设计附属工程施工组织设计清扫机器人结构设计 要求，弹出分 隔线条。用厚度约2?的胶带按照横墨线下边和 竖墨线的左边贴出分隔线线条，整条的贴。 B. 用裁纸刀切割不需要分割线部分和横竖重叠部分 胶带，而后分别揭去不需要分割线部分和横竖重 叠部分胶带。 (4)仿砖涂料施工 , 批刮质感仿砖涂料 用批刀按照胶带厚度批刮陶彩砖涂料，要求批刮密实，批刮收刀的方向一致。(如，劈开砖风格要求拉出横纹或竖纹) , 仅适合用于混拼色彩转的工艺 主色砖所批刮的陶彩砖涂料稍干后(约两天)沿着砖四周框重新贴上胶带而后批 刮混拼砖色彩的陶彩砖涂料。 (5)去除分格胶带 people. 6. measures to avoid loss of life or damage to property. 2.19 the mullion installation 1. Note: vertical installation in all curtain wall installation process due to its large amount of inconvenience of construction, high precision and play a very important role. If mullion is installed, the entire scheduleselect key, critical layer to clean, prevent debris impact on Ravel, identify key points and key layer fixed reinforced this point, and use on this level to take level so that horizontal lines as needed. (5) according to the curtain wall construction, simple key levels are not sufficient to determine the vertical position, in order to ensure the error limits of vertical installation, put the line ... Personnel 陶彩砖涂料稍干后(约10分钟)去除分割线条胶带，此时砖与缝既成型。 (6)清理、整修: ?清理:自检合格后，清除所有保护材料并清理对其它成品的污染，保持清洁的 施工面。 ?整修:因其它原因造成涂料表面破损或返色等，应将破损处补平，再依上述工 艺进行操作，收口处放在分格缝或阴阳角处，对于其它成品应严加保护。 5 people. 6. measures to avoid loss of life or damage to property. 2.19 the mullion installation 1. Note: vertical installation in all curtain wall installation process due to its large amount of inconvenience of construction, high precision and play a very important role. If mullion is installed, the entire scheduleselect key, critical layer to clean, prevent debris impact on Ravel, identify key points and key layer fixed reinforced this point, and use on this level to take level so that horizontal lines as needed. (5) according to the curtain wall construction, simple key levels are not sufficient to determine the vertical position, in order to ensure the error limits of vertical installation, put the line ... Personnel