AVIAN PEPSIN
Prepared at the 20th JECFA (1976), published in FNS 1B (1977) and in FNP
52 (1992). An ADI 'not specified' was established at the 20th JECFA (1976)
SYNONYMS None
SOURCES Commercial preparations of Avian Pepsin contain proteolytic enzymes
obtained from the forestomach (proventriculum) of chicken or turkey.
Active principles Pepsin (aspartic proteinase)
Systematic names and
numbers
None (EC 3.4.23.1)
Reactions catalyzed The enzyme preparations hydrolyzes polypeptides yielding peptides of lower
molecular weight. It clots milk.
Assay Activity not less than 85% and not more than 115% of the declared
DESCRIPTION Clear amber solution, tan suspension, or light tan powder
FUNCTIONAL USES Enzyme preparation
Used in clotting of milk in cheese making
GENERAL
SPECIFICATION
Must conform to the General Specifications for Enzyme Preparations used in
Food Processing (See Volume Introduction)
CHARACTERISTICS
IDENTIFICATION
Pepsin activity The sample shows milk clotting activity
See description in the Method of Assay
PURITY
Aflatoxin Not more than 5 µg/kg
Determine as directed in Journal of the AOAC 49, 544 (1966); Pons et al.,
Determination of Aflatoxins in Agricultural Products: Use of Aqueous
Acetone for Extraction.
Microbiological criteria
Salmonella spp.
Negative
Determine as directed in Section 10, Bacteriological Analytical Manual, 2nd.
Edition (1969), U.S. Department of Health, Education, and Welfare, or
Microbial Limit Tests, U.S.P. XIX, page 588.
Pseudomonas aeruginosa
Negative
Determine as directed under Microbial Limit Tests, U.S.P. XVIII, page 850, or
U.S.P. XIX, page 588.
Coliforms
Not more than 30 per g
Determine as directed in Section 41.009, Official Methods of Analysis of the
A.O.A.C., 11th Edition (1970), page 841.
Antibiotic activity Negative when examined by suitable methods
METHOD OF
ASSAY
Principle
Reconstituted milk is coagulated with an avian pepsin solution. The time
required to form visible clot is compared with that obtained with a reference
standard.
Definition of activity
The time of clotting T is related to the concentration C of active enzyme by
the relation T = to + kC where k is a proportionality factor which is constant
for the same batch of milk, under constant conditions of pH, temperature and
calcium ion concentration.
Procedure
To prepare the substrate solution, disperse 12 g of low-heat non-fat dry milk
powder in 94 ml of 0.01 M calcium chloride solution contained in a 100-ml
short-neck volumetric flask, stir magnetically 20-30 min then make up to
mark with 0.01 M calcium chloride solution. Distribute 10-ml portions in
separate test tubes and keep them at 30±0.2o for at least 10 min, but not
more than 1 h. To prepare the enzyme dilutions, introduce into 50-ml or 100-
ml volumetric flasks 2 ml and 4 ml respectively of 1.25 M sodium acetate
buffer pH 5.7, add distilled water to about two-thirds of the volume of the
flask and pipet accurately measured aliquots of the enzyme sample
(dissolve, if powdered), and the reference enzyme, dilute to volume. To
obtain the desired dilutions (about 1:5,000 strength, arrived at by diluting
original sample solution between 25 and 200 fold), distribute 1-ml aliquots of
each dilute enzyme solution in test tubes at (18x250 mm) and incubate at
30±0.2o.
To start the reaction pour rapidly the substrate solution contained in one test
tube into that containing the dilute enzyme and start concomitantly a stop
watch and mix the test solution twice by rapid inversion of the test tube and
keep in a slanted position in the water bath kept at 30±0.2o. Rotate the test
tube slowly by hand until the first clots are observed whereupon the watch is
stopped and the time is recorded to the nearest 0.1 sec.
Calculation
Plot the clotting times obtained with enzyme dilutions being assayed and that
with the reference standard against the dilution factors employed. Straight
lines are obtained for clotting times between 50 and 300 sec. The ratio of the
slopes of the lines are inversely proportional to the ratio between the
concentrations of enzyme.
AVIAN PEPSIN
SYNONYMS
Assay
DESCRIPTION
FUNCTIONAL USES
GENERAL SPECIFICATION
CHARACTERISTICS
IDENTIFICATION
Pepsin activity
PURITY
Aflatoxin
Microbiological criteria
Salmonella spp.
Pseudomonas aeruginosa
Coliforms
Antibiotic activity
METHOD OF
ASSAY
Principle
Definition of activity
Procedure
Calculation
本文档为【AVIAN PEPSIN-禽胃蛋白酶】,请使用软件OFFICE或WPS软件打开。作品中的文字与图均可以修改和编辑,
图片更改请在作品中右键图片并更换,文字修改请直接点击文字进行修改,也可以新增和删除文档中的内容。
该文档来自用户分享,如有侵权行为请发邮件ishare@vip.sina.com联系网站客服,我们会及时删除。
[版权声明] 本站所有资料为用户分享产生,若发现您的权利被侵害,请联系客服邮件isharekefu@iask.cn,我们尽快处理。
本作品所展示的图片、画像、字体、音乐的版权可能需版权方额外授权,请谨慎使用。
网站提供的党政主题相关内容(国旗、国徽、党徽..)目的在于配合国家政策宣传,仅限个人学习分享使用,禁止用于任何广告和商用目的。